Product ID:SUP-R-SET 392 PART B
MSDS Date:03/15/1991
FSC:8040
NIIN:00N033854
Kit Part:Y
MSDS Number: BPTNC

GUNNEBO FASTENING CORP

180 SOUTH HARTMAN STREET
YORK, PA 17405
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 717-846-2200; 800-336-1640

Cage: GUNNE

GUNNEBO FASTENING CORP

YORK, PA 17405 US

Telephone: 717-846-2200; 800-336-1640

Cage: GUNNE

CALCIUM CARBONATE; (LIMESTONE (PULVERIZED)) (MFR CAS

CAS: 1317-65-3

RTECS: EV9580000

OSHA PEL 15MG/M3 TDUST;5 RESP

ACGIH TLV: 10 MG/M3 TDUST

BENZOYL PEROXIDE (SARA III)

CAS: 94-36-0

RTECS: DM8575000

OSHA PEL 5 MG/M3

ACGIH TLV: 5 MG/M3

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:CAUSES EYE BURNS. SKIN IRRITANT. CAN
HAVE NARCOTIC EFFECT IF INHALED. CAN CAUSE ALLERGIC SKIN &
RESPIRATORY CONDITION.
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:SKIN & EYE CONDITIONS.

First Aid:EYES:IMMED FLUSH W/PLENTY OF H*2O FOR AT LST 15 MINS. CALL
MD. SKIN:WASH W/SOAP & H*2O. REMOVE CONTAM CLTHG & LAUNDER BEFORE
REUSE. INHAL:MOVE VICTIM TO FRESH AIR. GIVE O*2 &/OR ARTF RESP IF
NEEDED. C ALL MD. INGEST:GIVE PLENTY OF H*2O TO DRINK. DO NOT
INDUCE VOMIT. CALL MD. NEVER GIVE ANYTHING BY MOUTH TO UNCON PERS.
OTHER:REFERRAL TO MD IS REC IF THERE IS ANY QUESTION ABOUT
SERIOUSNESS OF(SUPDAT)

Flash Point:93.0F,33.9C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . COOL W/WATER SPRAY.
Unusual Fire/Explosion Hazard:ISOLATE FROM HEAT, ELEC EQUIP, SPKS &
OPEN FLAME. DECOMP & COMBUST PRODS MAY BE TOX. GLASS TUBES MAY
EXPLODE WHEN EXPOSED TO EXTREME HEAT.

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION. COVER
W/ABSORBENT MATERIAL & PLACE IN SALVAGE CONTAINER FOR PROPER
DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:KEEP IN A COOL DRY PLACE OUT OF DIRECT
RAYS OF SUN. STORE <100F. KEEP AWAY FROM IGNIT SOURCES SUCH AS
EXCESS HEAT, SPKS & OPEN FLAME.
Other Precautions:AVOID CONTACT W/EYES, SKIN & CLOTHING. AVOID
BREATHING VAPOR. AVOID PROLONGED OR REPEATED CONTACT W/SKIN. USE
W/ADEQUATE VENTILATION.

Respiratory Protection:USE NIOSH/MSHA APPROVED ORGANIC VAPOR RESPIRATOR
WHEN VAPOR CONCENTRATIONS EXCEED RECOMMENDED EXPOSURE LIMITS.
Ventilation:GENERAL (NATURAL OR MECHANICALLY INDUCED FRESH AIR
MOVEMENTS THAT MAINTAIN VAP CONCS BELOW RECOM EXPOS LIMITS).
Protective Gloves:IMPERMEABLE (NEOPRENE/RUBBER) GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:EMERGENCY EYE WASH & DELUGE SHOWER .
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
BP:DECOMPOSES ABOVE 150F, 66C. FIRST AID PROC:INJURY/EXPOSURE.

Boiling Pt:B.P. Text:SUPP DATA
Spec Gravity:1.42
Solubility in Water:NIL
Appearance and Odor:WHITE POWDER (INNER TUBE)

Stability Indicator/Materials to Avoid:YES
STRONG ACIDS, PEROXIDES & OTHER OXIDIZING AGENTS.
Stability Condition to Avoid:BENZOYL PEROXIDE WILL DECOMPOSE AT
TEMPERATURES >150F.
Hazardous Decomposition Products:CO*2, CO.

Waste Disposal Methods:CONSULT W/LOCAL REGULATORY AGENCIES OR CORPORATE
PERSONNEL FOR DISPOSAL METHODS THAT COMPLY W/LOCAL, STATE & FEDERAL
HEALTH ENVIRONMENTAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.